Конструювання, виробництво та експлуатація сільськогосподарських машин. Загальнодержавний міжвідомчий науково-технічний збірник.
Permanent URI for this communityhttps://dspace.kntu.kr.ua/handle/123456789/19
Ідентифікатор медіа: R30-03925 (рішення Національної ради України від 25.04.2024 р. № 1418).
Мови видання: українська, російська, англійська, періодичність - один раз на рік.
Browse
2 results
Search Results
Item Експериментальні дослідження ефективності функціонування систем забезпечення мікроклімату від’ємного тиску в тваринницьких приміщеннях(ЦНТУ, 2023) Калетнік, Г. М.; Яропуд, В. М.; Kaletnik, Н.; Yaropud, V.Обґрунтування раціональної схеми системи забезпечення мікроклімату від’ємного тиску в тваринницьких приміщеннях на основі виробничих обстежень є основною метою проведених досліджень. За результатами досліджень встановлено, що для тваринницького приміщення із системою вентиляції наземного каналу забезпечується більше свіжого повітря в зоні перебування тварин, у порівняні зі стельовою системою вентиляції і системою вентиляції через стінові канали. The microclimate of livestock premises is determined by a set of physical, chemical and biological parameters inside the premises for keeping animals and is characterized by the following parameters: air temperature, internal surfaces of walls, ceilings, floors, windows, doors, and other internal structures; humidity of air, internal surfaces of walls, ceiling, floor, windows, doors, and other internal structures; the speed and direction of air flows in the locations of animals, manure, inflow and exhaust channels, windows and doors; the gas composition of the air - the concentration of carbon dioxide, ammonia, hydrogen sulfide, carbon monoxide; the presence of dust and microorganisms in the air; the intensity of natural and artificial lighting; optical radiation; the level of industrial noise, the degree of air ionization. The substantiation of the rational scheme of the negative pressure microclimate system in livestock premises on the basis of production surveys is the main goal of the conducted research. According to the results of the research, it was found that for the livestock room with the ventilation system of the ground channel, more fresh air is provided in the area where the animals are staying, in comparison with the ceiling ventilation system and the ventilation system through the wall channels. For the ground duct ventilation system and the wall duct ventilation system, the efficiency of contaminant removal was influenced by the ventilation rate, which is significantly dependent on the animal's age, weight, and outdoor temperature. For the ventilation system of the above-ground channel in production conditions, the efficiency of pollution removal decreased with an increase in the speed of the air flow in the ventilation. For the wall duct ventilation system, the efficiency of pollutant removal increased as the ventilation air flow rate increased, as the sampling point was located at the back of the room. In a room with a ceiling ventilation system, the efficiency of contaminant removal was significantly influenced by the lying behavior of animals, and a slight decrease in the efficiency of contaminant removal was observed with increasing ventilation.Item Результати дослідження процесу сухого очищення забрудненої вовни(КНТУ, 2013) Шевченко, І. А.; Лиходід, В. В.; Алієв, Е. Б.; Полюсов, В. В.; Shevchenko, Igor; Lykhodid, Viktor; Aliyev, Elchin; Polusov, VasilyНаведено основні результати експериментальних досліджень малогабаритної тріпальної машини МТ 001А-12 при сухому очищенні забрудненої вовни та відображено оптимальне поєднання факторів, які здебільшого впливають на її роботу. Отримано математичну модель, яка адекватно описує робочий процес сухого очищення забрудненої вовни. Визначено оптимальні значення конструктивно-технологічних параметрів запропонованої конструкції малогабаритної тріпальної машини. Отримані результати досліджень є основою для удосконалення робочих органів існуючих конструкцій малогабаритних тріпальних машин аналогічного призначення. The aim of the research is to improve the process of dry cleaning polluted оvine wool by improving the construction of compact scutching machine. Presented the main results of experimental studies of compact scutching machine TM-001A-12 for dry cleaning polluted оvine wool and displayed an optimum combination of factors that primarily affect its work. A mathematical model that adequately describes the working process of dry cleaning polluted wool is obtained. Еxperimentally determined оptimum values of design and technological parameters of the proposed design of compact scutching machine with minimum energy costs for the implementation of working process. Experimentally set that the proposed design of the product performs stable technological process and provides degree of purification of polluted wool from 43,1 to 56,3%, which meets the requirements for this type scutching machine (at least 40%). The obtained results of research are the basis for the improvement of the working bodies of existing designs scutching machines similar purpose.